check engine FORD KUGA 2010 1.G Owner's Manual

•
Park your vehicle at the roadside so
that you do not obstruct the flow of
traffic and so that you are able to use
the kit without being in danger.
• Apply the parking brake, even if you
have parked on a level road, to make
sure that the vehicle will not move.
• Do not attempt to remove foreign
objects like nails or screws penetrating
the tyre.
• Leave the engine running while the kit
is in use, but not if the vehicle is in an
enclosed or poorly ventilated area (for
example, inside a building). In these
circumstances, switch the
compressor on with the engine turned
off.
• Replace the sealant bottle with a new
one before the expiry date (see top
of bottle) is reached.
• Inform all other users of the vehicle
that the tyre has been temporarily
sealed with the tyre repair kit and
make them aware of the special
driving conditions to be observed.
Inflating the tyre WARNINGS
Check the sidewall of the tyre prior
to inflation. If there are any cracks,
bumps or similar damage, do not
attempt to inflate the tyre. Do not stand directly beside the tyre
while the compressor is pumping.
Watch the sidewall of the tyre. If any
cracks, bumps or similar damage
appear, turn off the compressor and
let the air out by means of the pressure
relief valve B. Do not continue driving with
this tyre. WARNINGS
The sealant contains natural rubber
latex. Avoid contact with skin and
clothing. If this happens, rinse the
affected areas immediately with plenty of
water and contact your doctor. If the tyre inflation pressure does not
reach 1.8 bar (26 psi) within seven
minutes, the tyre may have suffered
excessive damage, making a temporary
repair impossible. In this case, do not
continue driving with this tyre. CAUTION
Screwing the bottle onto the bottle
holder will pierce the seal of the
bottle. Do not unscrew the bottle
from the holder as the sealant will escape. 162
Wheels and tyres

Protective cap
A
Pressure relief valve
B
Hose
C
Orange cap
D
Bottle holder
E
Pressure gauge
F
Power plug with cable
G
Compressor switch
H
Label
I Bottle lid
J
Sealant bottle
K
1. Open the lid of the tyre repair kit.
2. Peel off the label Ishowing the
maximum permissible speed of
80 km/h (50 mph) from the casing
and attach it to the instrument panel
in the driver’s field of view. Make sure
the label does not obscure anything
important.
3. Take the hose Cand the power plug
with cable Gout of the kit.
4. Unscrew the orange cap Dand the
bottle lid J.
5. Screw the sealant bottle Kclockwise
into the bottle holder Efully tight.
6. Remove the valve cap from the damaged tyre.
7. Detach the protective cap Afrom the
hose Cand screw the hose Cfirmly
onto the valve of the damaged tyre.
8. Make sure that the compressor switch
His in position 0.
9. Insert the power plug Ginto the cigar
lighter socket or auxiliary power
socket. See Cigar lighter (page 97).
See Auxiliary power sockets
(page 97).
10. Start the engine.
11. Move the compressor switch Hto
position 1.
12. Inflate the tyre for no longer than seven minutes to an inflation
pressure of minimum 1.8 bar (26 psi)
and a maximum of 3.5 bar (51 psi).
Move the compressor switch Hto
position 0and check the current tyre
pressure with pressure gauge F.
13. Remove the power plug Gfrom the
cigar lighter socket or auxiliary power
socket.
163
Wheels and tyresE94973BJIFECKAGHD

Note:After the installation of RF
transmitters, check for disturbances from and to all electrical equipment in thevehicle, both in the standby and transmitmodes.
Check all electrical equipment:
• with the ignition
ON
• with the engine running
• during a road test at various speeds.
Check that electromagnetic fields
generated inside the vehicle cabin by the
transmitter installed do not exceed human
exposure limits specified in EU directive
2004/40/EC.
214
Appendices

Booster cables
See: Using booster cables........................154
Booster cushions.....................................19 Booster cushion (Group 3)..........................19
Booster seat (Group 2)................................19
Brake and clutch fluid check...............149
Brakes......................................................112 Principle of operation..................................112
Bulb changing See: Changing a bulb..................................52
Bulb specification chart..........................58
C
Car wash See: Cleaning the exterior.........................152
Catalytic converter................................105 Driving with a catalytic converter.............105
CD changer..............................................99
Changing a bulb......................................52 Approach lamp.............................................53
Central high mounted brake lamp............56
Front fog lamps............................................54
Headlamp...................................................... 52
Interior lamp..................................................56
Luggage compartment lamp.....................58
Number plate lamp......................................56
Reading lamps..............................................57
Rear fog lamps.............................................54
Rear lamps....................................................55
Side repeaters..............................................53
Vanity mirror lamp.........................................57
Changing a fuse....................................134
Changing a road wheel........................156 Assembling the wheel brace....................158
Installing a road wheel...............................160
Jacking and lifting points............................157
Locking wheel nuts....................................156
Removing a road wheel............................159
Removing the wheel trim..........................159
Vehicle jack..................................................156
Vehicles with a temporary spare
wheel........................................................ 156
Changing the remote control battery....................................................27
Changing the wiper blades...................44 Rear window wiper blade...........................45
Windscreen wiper blades...........................44 Checking the wiper blades...................43
Child safety...............................................16
Child safety locks.....................................21
Left-hand side...............................................21
Right-hand side.............................................21
Child seat positioning..............................17 All vehicles......................................................17
Vehicles with under floor storage...............17
Child seats................................................16 Child restraints for different mass
groups........................................................ 16
Cigar lighter..............................................97
Cleaning the exterior............................152 Body paintwork preservation...................152
Cleaning the chrome trim.........................152
Cleaning the headlamps...........................152
Cleaning the rear window.........................152
Cleaning the interior..............................152 Instrument cluster screens, LCD screens,
radio screens..........................................153
Seat belts.....................................................152
Climate control........................................80 Principle of operation...................................80
Climate control commands.................197 Climate.......................................................... 197
Coded keys.............................................36
Cold weather precautions....................131
Connecting an external device...........201 Connection.................................................. 201
Connecting an external device - Vehicles With: Bluetooth....................201
Connecting a Bluetooth audio device....................................................... 201
Connectivity...........................................200 General information...................................200
Convenience features............................96
Coolant check See: Engine coolant check.......................148
Cruise control.........................................120 Principle of operation.................................120
Cruise control See: Using cruise control..........................120
Cup holders.............................................96 Seat back trays.............................................96
216
Index

D
Detachable tow ball...............................127
Driving with a trailer....................................129
Inserting the tow ball arm..........................128
Maintenance............................................... 129
Removing the tow ball arm.......................129
Unlocking the tow ball arm mechanism.............................................. 128
Diesel particulate filter (DPF)................102 Regeneration............................................... 103
Direction indicators.................................50
Disabling the passenger airbag............25 Disabling the passenger airbag.................26
Enabling the passenger airbag..................26
Fitting the passenger airbag deactivation
switch......................................................... 25
Disarming the alarm................................37 Britain and Ireland only................................38
Disarming the engine immobiliser........36
DPF See: Diesel particulate filter (DPF)............102
Driving hints.............................................131
Driving through water............................131 Driving through water ................................131
E
Electric exterior mirrors..........................62 Electric folding mirrors.................................62
Mirror tilting positions...................................62
Electric seats...........................................93 6-way electric seat......................................93
Electric windows.....................................60 Anti-trap function..........................................60
Driver's door switches.................................60
Global opening and closing........................60
Opening and closing the windows
automatically............................................. 60
Resetting the memory of the electric windows..................................................... 61
Safety switch for rear windows.................60
Electromagnetic compatibility.............212
Emergency equipment........................132
Engine compartment overview - 2.0L Duratorq-TDCi (DW) Diesel...............145
Engine compartment overview - 2.5L Duratec (VI5)........................................144 Engine coolant check...........................148
Checking the coolant level........................148
Topping up...................................................148
Engine immobiliser..................................36 Principle of operation...................................36
Engine oil check.....................................147 Checking the oil level..................................147
Topping up...................................................148
Engine oil dipstick - 2.0L Duratorq-TDCi (DW) Diesel...........................................147
Engine oil dipstick - 2.5L Duratec (VI5).......................................................147
Exterior mirrors.........................................61 Manual folding mirrors..................................61
F
Fastening the seat belts........................24
First aid kit...............................................132
Floor mats...............................................100
Fog lamp See: Front fog lamps....................................47
Front fog lamps.......................................47
Fuel and refuelling.................................104 Technical specifications.............................106
Fuel burning heater See: Auxiliary heater....................................86
Fuel consumption..................................106
Fuel consumption See: Technical specifications....................106
Fuel cut-off switch.................................133 Vehicles with a Duratec engine................133
Fuel filler flap...........................................104
Fuel quality - Diesel...............................104 Long-term storage.....................................104
Fuel quality - Petrol................................104
Fuse box locations................................134 Engine compartment fuse box................134
Passenger compartment fuse box.........134
Fuses.......................................................134
Fuse specification chart.......................135 Engine compartment fuse box................135
Passenger compartment fuse box.........137
217
Index

L
Lighting control........................................46
Headlamp flasher.........................................46
Home safe lighting.......................................46
Lighting control positions............................46
Main and dipped beam...............................46
Parking lamps...............................................46
Lighting.....................................................46
Load carriers See: Roof racks and load carriers............124
Load carrying.........................................122 General information....................................122
Locking and unlocking...........................29 Automatic relocking......................................31
Central locking..............................................29
Double locking..............................................29
Double locking the doors with the
key.............................................................. 29
Locking and unlocking confirmation.........29
Locking and unlocking the doors and the luggage compartment lid with the
remote control..........................................29
Locking and unlocking the doors from inside.......................................................... 30
Locking and unlocking the doors with the key.............................................................. 29
Luggage compartment lid..........................30
Reprogramming the unlocking function....................................................... 31
Locks.........................................................29
Luggage anchor points........................122
Luggage covers....................................122 Stowing the luggage cover - vehicles with
tyre repair kit............................................123
M
Maintenance..........................................142 General information....................................142
Technical specifications.............................150
Manual climate control............................81 Air conditioning.............................................82
Air distribution control...................................81
Blower............................................................. 81
Heating the interior quickly..........................81
Recirculated air..............................................81
Ventilation...................................................... 82Manual seats............................................91
All vehicles......................................................91
Manual transmission.............................108
Message centre See: Information displays............................68
Mirrors See: Heated windows and mirrors...........86
See: Windows and mirrors.........................60
N
Navigation introduction........................208
Navigation system commands...........197
Navigation system................................209
O
Occupant protection..............................22 Principle of operation...................................22
Oil check See: Engine oil check.................................147
See: Opening and closing the bonnet.....142
O
Opening and closing the bonnet........142 Closing the bonnet.....................................143
Opening the bonnet...................................142
P
Parking aid...............................................115 Principle of operation..................................115
Parking aid See: Using the parking aid.........................115
Parking brake..........................................112 All vehicles....................................................112
Parts and accessories..............................5 Look for the Ford logo on the following
parts .............................................................6
Now you can be sure that your Ford parts are Ford parts.............................................5
219
Index

Personalised settings..............................71
Chime deactivation......................................73
Clock setting..................................................71
ESP.................................................................. 71
Help screen and navigation information................................................ 72
Language setting.........................................72
Navigation information.................................72
Steering........................................................... 71
Units of measure..........................................73
Power steering fluid check..................149 Topping up...................................................149
Programming the remote control........27
Q
Quick start..................................................8 Adjusting the steering wheel.......................12
Airbag.............................................................. 15
Autolamps...................................................... 14
Automatic climate control...........................14
Autowipers..................................................... 14
Direction indicators.......................................14
Instrument panel overview...........................8
Keyless entry.................................................12
Keyless starting.............................................12
Locking and unlocking..................................11
Manual climate control.................................13
Manual transmission.....................................15
Towing the vehicle on four wheels.............15
R
Rear fog lamps........................................47
Rear seats................................................94 Creating a level load floor...........................94
Folding the seatbacks down......................94
Folding the seatbacks up...........................94
Rear under floor storage......................123
Rear view camera..................................117 Principle of operation..................................117
Rear window wiper and washers.........42 Intermittent wipe..........................................42
Rear window washer...................................43
Reverse gear wipe.......................................42
Refuelling................................................106 Remote control battery
See: Changing the remote control
battery........................................................ 27
Remote control programming See: Programming the remote control.....27
Removing a headlamp............................51
Repairing minor paint damage............153
Road Safety...........................................208 Safety information......................................208
Roof racks and load carriers...............124 Cycle carrier................................................125
Installing the crossbars..............................124
Roof rack......................................................124
Run flat tyres..........................................165 Principle of operation.................................165
Replacing run flat tyres..............................165
What to do if a run flat tyre has a
puncture.................................................. 165
Running-in...............................................131 Brakes and clutch.......................................131
Engine........................................................... 131
Tyres.............................................................. 131
S
Safety precautions................................104
Seat belt height adjustment..................24
Seat belt reminder..................................24 Deactivating the seat belt reminder..........25
Seats.........................................................90
Sitting in the correct position.................90
Snow chains See: Using snow chains............................166
Speed control See: Cruise control.....................................120
Stability control........................................113 Principle of operation..................................113
Stability control See: Using stability control.........................113
Starting the engine.................................101 General information....................................101
Status after a collision...........................133
Steering wheel.........................................39
Storage compartments.........................98 Front storage compartment......................98
Storage area under the rear seats............98
Sun blinds.................................................96 Panoramic roof.............................................96
220
Index

Switching off the engine.......................103
Vehicles with a turbocharger....................103
Symbols glossary......................................5 Symbols in this handbook.............................5
Symbols on your vehicle...............................5
T
Technical specifications.........................171 Technical specifications..............................171
Telephone commands.........................192 Create a phonebook.................................195
Main settings...............................................197
Phone........................................................... 192
Phone functions..........................................193
Telephone controls................................177 Remote control...........................................177
Telephone setup....................................175 Bond another Bluetooth phone...............176
Making a phone an active phone............175
Phonebook.................................................. 175
Phonebook categories..............................175
Telephone...............................................175 General information....................................175
Telephone See: Using the telephone - Vehicles With:
Navigation System.................................180
See: Using the telephone - Vehicles Without: Navigation System..................................177
Toll reader.................................................99
Towing a trailer.......................................127 Steep gradients...........................................127
Towing points.........................................140
Towing the vehicle on four wheels..................................................140
All vehicles....................................................140
Vehicles with automatic transmission............................................. 141
Towing.....................................................127
Transmission..........................................108
Type approvals.......................................211 FCC/INDUSTRY CANADA NOTICE..........211
RX-42 - declaration of conformity............211
Tyre care.................................................166
Tyre pressure monitoring system.......167 System reset...............................................167
Tyre pressures See: Technical specifications....................168 Tyre repair kit...........................................161
Checking the tyre pressure......................164
General information....................................161
Inflating the tyre...........................................162
Using the tyre repair kit...............................161
Tyres See: Wheels and tyres...............................156
U
USB port.................................................100
Using an iPod........................................204 CD Navigation units...................................206
DVD Navigation units.................................206
Sony radio...................................................205
Using a USB device..............................202 CD Navigation units...................................203
DVD Navigation units.................................204
Sony radio...................................................202
Using booster cables............................154 To connect the booster cables................154
To start the engine.....................................155
Using cruise control..............................120 Cancelling the set speed...........................121
Changing the set speed............................120
Resuming the set speed............................121
Setting a speed...........................................120
Switching cruise control off.......................121
Switching cruise control on.......................120
Using seat belts during pregnancy......25
Using snow chains................................166 Vehicles with stability control (ESP)..........167
Using stability control.............................113
Using the parking aid.............................115 Manoeuvring with the parking aid............115
Switching the parking aid on and off........115
Using the rear view camera..................117 Activating the rear view camera...............117
Deactivating the rear view camera..........119
Using the display..........................................117
Vehicles with parking aid............................119
221
Index

Using the telephone - Vehicles With:
Navigation System..............................180
Changing the active phone.......................181
Debonding a bonded phone.....................181
Making a call................................................180
Muting the microphone.............................180
Receiving an incoming call........................180
Receiving a second incoming call............180
Using the telephone - Vehicles Without: Navigation System..............................177
Changing the active phone.......................179
Debonding a bonded phone....................179
Debonding a bonded phone - Sony radio.......................................................... 179
Making a call................................................177
Muting the microphone.............................179
Receiving an incoming call........................178
Receiving a second incoming call............178
Using voice control...............................182 Name tag.....................................................183
System operation.......................................182
Using winter tyres..................................166
V
Vehicle battery.......................................154
Vehicle care............................................152
Vehicle identification number (VIN).......................................................170
Vehicle identification plate....................170
Vehicle identification..............................170
Vehicle recovery....................................140
Ventilation See: Climate control....................................80
Vents See: Air vents................................................80
VIN See: Vehicle identification number
(VIN).......................................................... 170
Voice control............................................40 Principle of operation.................................182 W
Warning lamps and indicators..............64
ABS warning lamp........................................64
Airbag warning lamp....................................64
Brake system lamp......................................64
Cruise control indicator...............................64
Direction indicators......................................64
Doors open warning lamp..........................64
Engine warning lamp...................................65
Front fog lamp indicator..............................65
Frost warning lamp......................................65
Glow plug indicator......................................65
Headlamp indicator......................................65
Ignition warning lamp...................................65
Low fuel level warning lamp.......................65
Main beam indicator....................................65
Message indicator.......................................65
Oil pressure warning lamp..........................65
Power steering warning lamp....................66
Rear fog lamp indicator...............................66
Seat belt reminder.......................................66
Shift indicator................................................66
Stability control (ESP) indicator..................66
Warning triangle.....................................132
Washer fluid check................................149
Washers See: Wipers and washers............................41
Washing See: Cleaning the exterior.........................152
Wheels and tyres...................................156 General information....................................156
Technical specifications.............................168
Windows and mirrors.............................60
Windscreen washers.............................42
Windscreen wipers..................................41 Automatic wiper system..............................41
Intermittent wipe...........................................41
Winter tyres See: Using winter tyres..............................166
Wipers and washers...............................41
222
Index